• 全部
主办单位:煤炭科学研究总院有限公司、中国煤炭学会学术期刊工作委员会
低压磨料空气射流切割硬岩评价模型及应用
  • Title

    An evaluation model and its application of low-pressure abrasive air jet slitting hard rock

  • 作者

    魏建平蔡玉波张铁岗薛熠姬松涛陈长江张慧栋刘勇

  • Author

    WEI Jianping;CAI Yubo;ZHANG Tiegang;XUE Yi;JI Songtao;CHEN Changjiang;ZHANG Huidong;LIU Yong

  • 单位

    河南理工大学 瓦斯地质与瓦斯治理国家重点实验室培育基地煤炭安全生产与清洁高效利用省部共建协同创新中心西安理工大学 土木建筑工程学院西安科技大学 教育部西部矿井开采及灾害防治重点实验室

  • Organization
    State Key Laboratory Cultivation Base for Gas Geology and Gas Control, Henan Polytechnic University
    State Collaborative Innovation Center of Coal Work Safety and Clean-efficiency Utilization
    School of Civil Engineering and Architecture, Xi’an University of Technology
    Key Laboratory of Western Mines and Hazard Prevention of Ministry of Education, Xi’an University of Science and Technology
  • 摘要

    低压磨料空气射流破岩能力强、能耗低,是一种解决硬岩掘进效率低、刀具损耗严重最具潜力的技术之一。但采用磨料射流技术进行破岩割缝时,由于评价指标(割缝深度、宽度、体积)单一、普适及通用性差,导致磨料射流在不同工况下的最佳割缝参数难以确定,极大限制了磨料射流技术的推广应用效果。为此,提出一种综合考虑磨料射流割缝深度、宽度和体积等缝槽参数之间定量关系的评价模型。通过对岩石割缝形貌进行三维重构,并进行均值化处理,得到射流割缝缝槽形态分布方程。将缝槽形态曲线方程的均值面积A与分布函数振幅a1的比值定义为割缝特征宽度b,并将ba1的比值定义为宽高比P。利用P对磨料射流割缝效果进行评判,得到如下结论:在P≤0.5时,表示能形成更窄更深的割缝,且当P越小时,割缝窄深特征更明显;当P>0.5时,表示能够形成更宽更浅的割缝。利用P对不同割缝参数条件下的割缝效果进行表征,得出当需要获得较深的割缝形态时,应控制射流冲击靶距为40 mm,磨料粒径在60~90目(0.16~0.25 mm),磨料莫氏硬度应控制在7.0以上,采用16 ~32 g/s的磨料质量流量和60°的冲击角度。当获得宽且浅的割缝形态时,可选择磨料粒径大于90目(0.16 mm),磨料莫氏硬度低于7.0,使磨料质量流量低于8 g/s并控制射流冲击角度超过75°,射流靶距大于40 mm。

  • Abstract

    Low-pressure abrasive air jet technology is one of the most promising methods for addressing the issues of low efficiency and significant tool wear in hard-rock drilling, owing to its strong rock-breaking capability and low energy consumption. However, the application of this technology faces challenges due to the reliance on single evaluation indices (e.g., slit depth, width, volume), which lack universality and generality, making it difficult to determine the optimal slit parameters under varying working conditions. This limitation significantly hampers the effectiveness of abrasive jet technology. To address this issue, proposes an evaluation model that integrates the quantitative relationships among slit parameters such as depth,width, and volume. A jet slit morphology distribution equation is derived through three-dimensional reconstruction and homogenization of rock slit morphology. The ratio of the mean area (A) of the slit morphology curve to the distribution function parameter (a1) is defined as the characteristic width of the slit, denoted as b, and the ratio of b to a1 is defined as the width-to-height ratio P. The effectiveness of the slit is evaluated using P, leading to the following conclusions: when P≤0.5, a narrower and deeper slit is formed; when P > 0.5, a wider and shallower slit is produced. By using P to characterize the slit effect under different parameter conditions, it is determined that when a deeper slit is required, the jet impact target distance should be maintained at 40 mm, the abrasive grain size should range between 60 and 90 mesh (0.16~0.25 mm), the abrasive hardness should exceed 7.0 on the Mohs scale, the mass flow rate of the abrasive should be between 16 g/s and 32 g/s, and an impact angle of 60° should be used. For obtaining a wide and shallow slit, the abrasive grain size should exceed 90 mesh (0.16 mm), the Mohs hardness should be less than 7.0, the abrasive mass flow rate should be lower than 8 g/s, the jet impact angle should be greater than 75°, and the distance between the jet and the target should be greater than 40 mm.

  • 关键词

    磨料空气射流硬岩切割割缝形貌评价模型割缝参数

  • KeyWords

    abrasive air jet;hard rock slitting;slitting shape;evaluation model;slit parameters

  • 基金项目(Foundation)
    国家自然科学基金资助项目(U24A2091, 52374193);河南省重点研发专项资助项目(231111322000)
  • DOI
  • 引用格式
    魏建平,蔡玉波,张铁岗,等. 低压磨料空气射流切割硬岩评价模型及应用[J]. 煤炭学报,2025,50(1):349−359.
  • Citation
    WEI Jianping,CAI Yubo,ZHANG Tiegang,et al. An evaluation model and its application of low-pressure abrasive air jet slitting hard rock[J]. Journal of China Coal Society,2025,50(1):349−359.
  • 相关文章
  • 图表

    图(0) / 表(1)

相关问题
立即提问

主办单位:煤炭科学研究总院有限公司 中国煤炭学会学术期刊工作委员会

©版权所有2015 煤炭科学研究总院有限公司 地址:北京市朝阳区和平里青年沟东路煤炭大厦 邮编:100013
京ICP备05086979号-16  技术支持:云智互联